2001 Ford Expedition Xlt Sport Utility 4-door 5.4l on 2040-cars

Auto blog

Ford settles class action suit over defective Navistar diesel engines

The 2003 Ford F-Series Super Duty (shown above) introduced the 6.0-liter Power Stroke diesel supplied by Navistar, and while that is an engine Ford would love to forget, it's now one step closer to putting that particular problem behind it. Automotive News is reporting that Ford has settled a class-action lawsuit brought on by problems with this engine that started right out of the gate and ultimately broke up the 30-year relationship between Ford and Navistar.
Owners and lessees of 2003-2007 Super Duty trucks and E-Series vans equipped with the 6.0-liter Power Stroke are eligible for deductible reimbursements of between $50 and $200 from the original five-year/100,000-mile engine warranty, while Ford is paying out as much as $825 for out-of-warranty engine repairs. These repairs may include the exhaust gas recirculation (EGR) cooler, EGR valve, oil cooler, fuel injectors and turbocharger, but are only covered if the components failed before six years or 135,000 miles.
In total, Ford has agreed to pay about 50 percent of the value of the repairs and deductibles paid by its customers who submit a claim before the end of this year, and $150,000 is going to the 16 named plaintiffs in the case; Navistar was not included in the lawsuit.

How Ford made its 2015 Ford Mustang safer for toupee wearers [w/video]

Ford is ready to tell the story of its 2015 Mustang Convertible, the can't-miss bits being the easier, quicker and quieter roof operation, a more robust roof build for a coupe-like cabin noise, more trunk space, better visibility and reduced in-cabin buffeting. The top release system has been completely redesigned with a single, center-mounted latch on the windshield frame instead of the dual latches of before. The driver can now release the roof without having to lean over into the passenger space, after which the top goes down fully automatically with the press of a button. Ford doesn't say how long it takes to stow, but it's apparently done in half as much time as before, so figure around 8 seconds.
The roof uses a five-bow structure, with the fabric outer and full inner headliner sandwiching ten millimeters of insulation. Detailing work on the top has eliminated "unsightly folds" in the corners when the roof is up and made it more compact when down; its Z-fold assembly is 6.7 inches lower than before at its highest point when put down. Ford says the new electric drive internals make less noise when in operation, and the fully-finished droptop look is achieved with snap-in caps that flank the rear seating and stow in the trunk when not in use (the outgoing Mustang's top was higher and the front when folded and always looked like it was catching air and creating drag).
The compact roof and newly independent rear suspension setup in back means liberated trunk space, 11.4 cubic feet ready to swallow golf bags and tourist swag. You can read a lot more about it in the press release below, check it out in the short video of running footage and learn about the aerodynamic improvements made to the entire Mustang lineup that decrease drag and increase fuel economy.

2014 Ford Fusion to get 1.5L EcoBoost three-cylinder?

Just one year after launching the all-new 2013 Fusion, Ford is reportedly set to alter the sedan's powertrain lineup with the addition of a new 1.5-liter turbocharged three-cylinder EcoBoost engine. A member of Blue Oval Forums apparently got their hands on the ordering guide for the 2014 model year Fusion, and this 1.5-liter mill is set to be introduced with late availability.
This lines up with other news about the Chinese-market Mondeo being offered with a new 1.5-liter EcoBoost - a derivative of the 1.0-liter triple that will come to North America under the hood of the Fiesta (note: the 1.0 is also offered in the current Euro-spec Mondeo). In the Chinese application, the larger three-pot engine produces 177 horsepower and 177 pound-feet of torque, which is very close to the current 1.6-liter inline-four's output numbers of 178 hp and 184 lb-ft.
What's interesting, however, is that the 1.6-liter engine will reportedly still be offered in the Fusion, but only with the six-speed manual transmission. The smaller 1.5-liter EcoBoost will only be mated to a six-speed SelectShift automatic, and will feature start/stop. This means that while the 1.5 is slightly down on power compared to the 1.6, it could easily improve fuel economy numbers, allowing the Fusion to regain the title of having the best mileage in the segment, likely besting the 38 miles per gallon of the Nissan Altima. Currently, the Fusion 1.6 is rated at 23 mpg city and 36 mpg highway.