2007 Ford Expedition Xlt Sport Utility 4-door 5.4l on 2040-cars

Auto blog

Ford finally issues recall for 230K minivans over rust problems

The rust issue in the rear wheel wells of 2004-2007 Ford Freestar and Mercury Monterey minivans has finally led to a recall. The National Highway Traffic Safety Administration began an investigation into the matter in 2011, said investigation being upgraded to an engineering analysis a year later while NHTSA tried to figure out how many model years should be included in the assessment.
Ford has decided to recall all of the 230,000 minivans potentially affected, namely those sold in salt-belt states and countries like Canada. The excess rust in the rear wheel wells was also able to prevent the third-row seats from locking to the floor of the minivan. To repair the problem, owners can take their minivans to dealers, and the dealers will place new panels in the wheel wells, replace the third-row seat mounting brackets and relocate the latches to an area away from any corrosion.
Ford says it will begin notifying owners during the last week of March.

Ford recalls select Explorer, E-Series vans

Just a few days ago we brought you news that Ford had issued a recall on 28,000 units of the Edge crossover for problems related to the fuel line. But now the Blue Oval has issued recall notices on two more of its larger vehicles.
The first relates to the Explorer, 395 examples of which from the 2011 and 2012 model years were found to have problems with their steering systems if they underwent service after September 1, 2013. An apparent software glitch could lock the steering gear, preventing the driver from steering the vehicle and thereby increasing the risk of a crash. As a result, Ford dealers are being instructed to check their records to identify the problematic vehicles and bring them in to have the steering gear replaced. Details of the recall can be found in the PDF linked here.
The second problem revolves around E-Series vans that may develop bubbles in their windshields under hot temperatures. The decrease in visibility through the problematic windshield could - you guessed it - "increase the risk of a crash." As a result, Ford is calling in 4,532 units of the E-150, E-250, E-350 and E-450 vans built in the relatively short window between May 12 and May 26, 2011. Details of this recall can be found in the notice below from the National Highway Traffic Safety Administration.

NHTSA will investigate some Ford Fusion, Lincoln MKZ models for power steering issue

The National Highway Traffic Safety Administration is opening an investigation into the 2010-2012 Ford Fusion, Fusion Hybrid and Lincoln MKZ, the 2012 MKZ Hybrid and 2011 Mercury Milan because the agency has hundreds of complaints of electric power steering failure in these models.
According to NHTSA's data, it has received 508 complaints of the power steering allegedly suddenly malfunctioning and resulting in increased effort to turn the wheel. In four incidents, these failures resulted in loss of control and crashes. According to the reports, in some cases a power steering warning message came on as the fault occurred, and other times the system restored itself by turning off and then restarting the vehicle. NHTSA said it has also received further field report data from Ford, but that information hasn't been publicly released yet.
For the moment, there isn't a recall for this failure on these models. NHTSA is just investigating them to "assess the scope, frequency and safety consequences of the alleged defect," and the agency says an estimated 938,000 vehicles could potentially be affected.