2004 Saturn Ion-2 Base Sedan 4-door 2.2l on 2040-cars

Auto blog

Saturn Vue ignition issue was discussed three times before recall, new documents reveal

Despite the tens of millions of recalled vehicles this year, it's somewhat rare that we get a glimpse into what goes into deciding when to conduct one of these safety campaigns. New documents published by General Motors and the National Highway Traffic Safety Administration are giving us an interesting opportunity to see how the sausage is made and show the number of meetings it takes to declare a recall.
In early August, GM added about another 269,000 vehicles to its 2014 recall tally in the US when it announced a slew of new safety campaigns. Among them was a fix for the 2002-2004 Saturn Vue that covered 202,155 of them in the US. The problem was that the key could be removed from the ignition even when it wasn't in the "OFF" position, and that had caused two crashes and one injury, according to the automaker.
Where we start to see behind the veil is in the defect notice freshly released by NHTSA. It shows that GM began investigating more widely for ignition switches in April, shortly after the company expanded its ignition switch recall to a variety of Saturn products, among others, according to Automotive News. The automaker found 152 reports in the 2002-2004 Vue of vehicles rolling away or the key being removed out of a total population of 215,243 units worldwide.

Saturn Ion steering probe closed by NHTSA

The National Highway Traffic Safety Administration has closed its investigation into faulty electric power steering motors affecting 334,728 Saturn Ions from 2004-2007, because General Motors has issued a recall for them. The group's research found that the part failed at a high rate in the vehicles.
GM recalled over 1.3 million vehicles a few weeks ago, including the Ion, because the power steering could suddenly fail. If broken, the cars could still turn, but it took greater effort. The automaker is also covering 96,324 2003 Ions with a lifetime warranty for their motors, but it's not immediately replacing them.
NHTSA opened its investigation into the motors in September 2011, and it found 4,787 complaints and 30,560 warranty claims that showed failure for the Ion alone. It estimated a complaint rate of 14.3 incidents per 1,000 vehicles and warranty claim rate of 9.1 percent. The investigation also found evidence of 12 crashes caused by loss of steering, two of which resulted in injuries.

GM recalling 426,000 sedans over faulty transmission shift cable

General Motors is recalling some 426,240 sedans that may have a faulty transmission shift cable, according to a National Highway Traffic Safety Administration report this morning. The recall concerns a fault within four-speed automatic transmissions equipped on 2007-2010 Saturn Aura models, and 2008-2010 Chevrolet Malibu and Pontiac G6 models.
The report specifies that tabs on the transmission shift cable may fracture and separate. Such a fault could cause a discrepancy between the actual position of the transmission and the apparent position of the shift lever.
GM is currently working to notify owners of the vehicles in question, and dealers will check and replace shift cables free of charge. Scroll down to read the complete NHTSA report.