2011 Tan One! on 2040-cars

Auto blog

Toyota to ramp up Tacoma production in Mexico by 41%

The Toyota Tacoma may be getting on in age, but that isn't stopping the Japanese manufacturer from ramping up production at the pickup's Baja California factory. The Mexican plant will soon be home to another 300 jobs as it increases total capacity by 41 percent. The increase is slated for April 2015.
The move is a curious one, considering the Tacoma's age and the fact that General Motors is preparing what, on the surface, appear to be two very competent challengers. The factory increase could be in preparation for the 2016 Taco (spy photos shown above), which is expected to represent a significant overhaul of the long-serving truck.
Toyota's decision to increase capacity could also be due to the factory building freeze implemented by President Akio Toyoda, according to Automotive News. Toyoda put a hold on new factories until 2016, asking executives to squeeze as much production as possible out of remaining factories before bringing any additional facilities online.

119K Toyota Avalon sedans recalled over airbag woes

Toyota has issued a voluntary safety recall for 119,000 2003-2004 Avalon models because in some cases the airbags could inadvertently deploy.
The automaker says that circuits within the airbag control module could be damaged by electrical noise, which could cause the front airbags and seatbelt pre-tensioners to activate. Dealers are going to repair cars by adding an electrical noise filter to the module. Owners will be notified by first class mail.
Toyota Public Affairs Manager Cindy Knight told Autoblog that there was one reported injury caused by the sudden deployment, but there have been no accidents or crashes. The company is currently preparing the parts for dealers now, and the component takes 90 minutes to two hours to install. "We don't believe there are any other affected models," said Knight.

Toyota Yaris Hybrid-R is road-going version of brand's racing technology [w/video]

Did you know that the Yaris is Toyota's best-selling vehicle in Europe? That may help explain to us Americans why the car that's lowest on the company's totem poll here in the US got turned into an all-wheel-drive hybrid track monster for the 2013 Frankfurt Monster Show.
Called the Toyota Yaris Hybrid-R, this three-door pocket rocket isn't just a hybrid making a lot of horsepower - it incorporates technology from Toyota's TS030 Hybrid racecar that competes in the FIA World Endurance Championship series, including the 24 Hours of Le Mans. The Yaris Hybrid-R packs a 300-horsepower, turbocharged, 1.6-liter four-cylinder engine under its hood, which should be enough for most speed freaks, but Toyota pairs it with two 60-hp electric motors at each rear wheel (the same ones used in the production Yaris Hybrid that's sold in Europe). That makes total system output an insane-for-this-size 420 hybrid horsies.
But that's not all, as the Yaris Hybrid-R forgoes the traditional battery pack below the rear seats in favor of a supercapacitor, which can both hold more energy and has a much faster power charge/discharge speed than traditional batteries. Paired with the supercapacitor is a third 60-hp electric motor/generator positioned between the engine and six-speed sequential transmission. Its job is to feed the super capacitor energy during deceleration and direct its power to the rear electric motors when more grip and oomph is needed.