2002 Volkswagen Beetle Gls Hatchback 2-door 2.0l on 2040-cars

Auto blog

BMW, Ferrari, VW cars use tungsten mined by terrorists

Bloomberg Markets is reporting that BMW, Volkswagen and Ferrari have been using tungsten ore sourced from Columbia's FARC rebel terrorists. The extensive story focuses on Columbia's illegal mining trade and calls into question the provenance of the rare ore that is used not only in crankshaft parts production, but is also found in the world's computing and telecommunications industry for use in screens.
The ore is mined by the FARC (Fuerzas Armadas Revolucionarias de Colombia, or Revolutionary Armed Forces of Colombia - People's Army), and exported to Pennsylvania, where it is refined. The refined ore is then sent over to Austria, where a company called Plansee turns it into a finished product. Now, it's important to note that we aren't talking about the world's supply of tungsten here. In 2012, Plansee's American refinery purchased 93.2 metric tons of tungsten, valued at $1.8 million. That's peanuts, with the entire Colombian tungsten mining industry producing just one percent of the world's supplies.
That doesn't make indirectly supporting FARC any more acceptable, though. BMW, VW and Ferrari are all committed to not accepting mineral supplies from the Democratic Republic of Congo, which is also in the grips of a guerrilla insurrection funded, in part, by illegal mining. The same commitment would figure to extend to Colombian mining, but as BMW points out, it's difficult for a multi-national manufacturer to know where every item in its supply chain comes from. A company spokesperson says as much, telling Bloomberg, "These few grams out of the billions of tons of raw materials passing through the BMW supply chain are of no practical relevance."

VW going turbo-only in 3 to 4 years

This really was a matter of when, rather than if. Volkswagen will apparently be the first manufacturer to phase out naturally aspirated engines in favor of turbocharging its full slate. VW is kind of responsible for ushering in this push towards small-displacement, turbocharged engines that's taken the industry by storm. When it dropped its direct-injection, 2.0-liter turbo in the 2005 GTI it demonstrated that strapping an iron long to an engine can enhance the powertrain as a whole. VW made fuel economy gains, while also giving a linear, non-laggy turbo experience that it has replicated, model-after-model, to this day.
Speaking with The Detroit News, Volkswagen's executive Vice President of Group Quality, Marc Trahan, told the paper that, "We only have one normally aspirated gas engine, and when we go to the next generation vehicle that it's in, it will be replaced. So three, four years maximum."
Really, it's hard to get teary-eyed about either of these engines going away. VW has access to smaller powerplants that could easily match the performance of the 2.5 five-cylinder and the 3.6 V6, while gobbling up less fuel and providing a better driving experience. What we are sad about is that a similar statement about the extinction of NA engines came from the Vice President of Powertrain Engineering at Ford, Joe Bakaj. We'd certainly get teary-eyed over a world without Ford's excellent 5.0-liter V8.

VW builds 250,000th Passat in Chattanooga in just two years

It hasn't been without incident or union organizing drive, but the Volkswagen plant in Chattanooga, TN has built its 250,000 Passat in just a little over two years. The Night Blue Passat TDI with black leather has come just two years and five weeks after the first customer car came off the line on April 18, 2011.
In the last year the plant operated at the 150,000-unit capacity that it was intended for, but the downturn in Passat sales and subsequent worker layoffs mean it will be a challenge to repeat the feat. The plant does have the world's largest solar park, though, and you can't take that away from them.
You'll find the official hand-clapping in the press release below.